[1]辛佳磊,季嘉晨,靳广超,等.船用柴油机废气余热利用系统性能研究[J].内燃机学报,2022,(06):561-568.
　Xin Jialei,Ji Jiachen,Jin Guangchao,et al.Performance Study of Exhaust Waste Heat Utilization System for a Marine Diesel Engine[J].,2022,(06):561-568.
点击复制

船用柴油机废气余热利用系统性能研究
分享到：

《内燃机学报》[ISSN:1006-6977/CN:61-1281/TN]

卷:
期数:
2022年06
页码:
561-568
栏目:
出版日期:
2022-11-25

文章信息/Info

Title:
Performance Study of Exhaust Waste Heat Utilization System for a Marine Diesel Engine
作者:
辛佳磊; 季嘉晨; 靳广超; 桂勇
中船动力研究院有限公司，上海 201206
Author(s):
Xin Jialei; Ji Jiachen; Jin Guangchao; Gui Yong
China Shipbuilding Power Engineering Institute Company Limited，Shanghai 201206，China
关键词:
船用柴油机; 有机朗肯循环; 余热利用; 能效设计指数
Keywords:
marine diesel engine; organic Rankine cycle; waste heat utilization; energy efficiency design index
分类号:
TK421.5
文献标志码:
A
摘要:
基于有机朗肯循环(ORC)的船用柴油机废气余热利用系统具有广阔的应用前景．对ORC废气余热利用系统开展配机性能试验，以探究不同主机负荷下该系统的性能．该系统以10MW级柴油主机废气为热源，采用五氟丙烷(R245fa)为有机工质，水为中间传热介质．结果表明：随着主机负荷上升，该系统的废气换热器效率上升，热水流量和R245fa流量上升，膨胀机进气压力抬升，过热度减小，发电效率、效率及发电量均增大．系统在最大工况下的净发电功率为263.05kW，发电效率达9.38%，效率达27.52%，螺杆膨胀机和工质泵的等熵效率分别为75.56%和39.47%．最后，基于试验结果得到该系统对一型120000 吨级远洋运输散货船的能效设计指数(EEDI)贡献度达3%；系统应用后的年燃料成本节省和静态投资回报期分别为1.4182×106元/年和3.29年．
Abstract:
Exhaust waste heat utilization system based on organic Rankine cycle(ORC)is promising in marine diesel engines. An experiment was conducted for an ORC exhaust waste heat utilization system to investigate the performance of the system under multiple engine loads. The system takes a 10MW marine diesel engine exhaust as the heat source，R245fa as the organic working fluid，and water as the intermediate heat transfer medium. The test results show that，as the engine load increases，the exhaust heat exchanger efficiency increases，hot water and R245fa flow rates increase，the pressure at the expander inlet increases，the superheat at the expander inlet decreases，the system efficiency，exergy efficiency and output power improve. Under the maximum system performance condition，the net output power is 263.05kW，with the system efficiency of 9.38% and exergy efficiency of 27.52%，the isentropic efficiencies of the screw expander and the pump are 75.56% and 39.47%，respectively. This indicates that the system presents great performance. Ultimately，based on the test results，the contribution approaches 3% for the ORC waste heat utilization system to the energy efficiency design index(EEDI) of a 120000 ton class bulk carrier，the annual fuel savings and payback period are around 141.82104 CNY/yr and 3.29 yr，respectively.

相似文献/References:

[1]史 磊,魏名山,马朝臣.膨胀器对车用余热回收系统性能影响的试验[J].内燃机学报,2015,(01):83.
　SHI Lei,WEI Ming-shan,MA Chao-chen.Experiment of the Influences of Scroll Expander on a Vehicle Waste Heat Recovery System[J].,2015,(06):83.
[2]覃 峰,郭丽华,苏 林,等.柴油机废热驱动有机朗肯循环的理论和试验[J].内燃机学报,2014,(03):260.
　QIN Feng,GUO Li-hua,SU Lin,et al.Theoretical and Experimental Analysis of an Organic Rankine Cycle Driven by Waste Heat from Diesel Engines[J].,2014,(06):260.
[3]杨 凯,张红光,张 健,等.混合工质和纯工质对柴油机余热回收系统性能影响的模拟[J].内燃机学报,2013,(05):449.
　YANG Kai,ZHANG Hong-guang,ZHANG Jian,et al.Simulation of the Effects of Mixed-Refrigerants and Pure Refrigerants on Diesel Engine Waste Heat Recovery System[J].,2013,(06):449.
[4]魏立队,段树林,邢 辉,等.船舶柴油机主轴承热弹性流体动力混合润滑分析[J].内燃机学报,2013,(02):183.
　WEI Li-dui,DUAN Shu-lin,XING Hui,et al.Thermo-Elasto-Hydrodynamic Behavior of Main Bearings of Marine Diesel Engines in Mixed Lubrication[J].,2013,(06):183.
[5]李静芬,郭丰泽,马有福,等.柴油机水下排气管倒流极限试验[J].内燃机学报,2016,(04):365.
　LI Jing-fen,GUO Feng-ze,MA You-fu,et al.Experiment on Zero Liquid Penetration Limits of an Underwater Exhaust Pipe for Marine Diesel Engines[J].,2016,(06):365.
[6]杨 灿,谢 辉,周 奎,等.柴油机有机朗肯循环余热回收系统的耦合效应[J].内燃机学报,2017,(05):452.
　Yang Can,Xie Hui,Zhou Kui,et al.Coupling Effects between a Diesel Engine and a the Subordinate ORC Exhaust Heat Recovery System[J].,2017,(06):452.
[7]牛晓晓,王贺春,李 旭,等.基于神经网络的柴油机性能预测模型优化[J].内燃机学报,2018,(06):561.
　Niu Xiaoxiao,Wang Hechun,Li Xu,et al.Optimization of Diesel Engine Responses Prediction Model Based on Neural Network[J].,2018,(06):561.
[8]马有福,彭杰伟,吕俊复,等.水平矩形管内气液两相逆向流动极限试验[J].内燃机学报,2019,(01):90.
　Ma Youfu,Peng Jiewei,Lü Junfu,et al.Experiment on Zero Liquid Penetration Limits in the Horizontal Pipe With Rectangular Cross-Section[J].,2019,(06):90.
[9]王 科,赵昌普,蔡玉洁,等.进气加湿与富氧对船用柴油机NOx-Soot排放的影响[J].内燃机学报,2020,(02):133.
　Wang Ke,Zhao Changpu,Cai Yujie,et al.Influence of Intake Air Humidification and Oxygen-Enriched on Marine Diesel Engine NOx-Soot Emissions[J].,2020,(06):133.
[10]范 玉,杨建国,贺玉海.衔铁打孔对高速电磁阀动态响应的影响[J].内燃机学报,2021,(05):472.
　Fan Yu,,et al.Effect of Armature Punching on Dynamic Response of High-Speed Solenoid Valve[J].,2021,(06):472.

更新日期/Last Update: 2022-11-25